油烟净化器是对餐饮油烟和恶臭污染物进行收集及净化处理的设备，几乎不管是在自己家里还是在饭店餐馆都能见到，那么您知道它的具体安装规范步骤吗？下面
济南油烟净化器厂家为您解答。
The lampblack purifier is a device for collecting and purifying cooking fume and malodorous pollutants. It can be seen almost at home or in restaurants. Do you know the specific installation procedures? Now Jinan lampblack purifier manufacturer will answer for you.
安装顺序：灶头→集烟罩→通风管道→油烟净化器→通风管道→风机，油烟净化器应安装在排风机之前，并且尽可能靠近集气罩，油烟净化器和管道应密封完好，无破损、无泄漏；
Installation sequence: stove → smoke collecting hood → ventilation duct → lampblack purifier → ventilation duct → fan. The lampblack purifier should be installed in front of the exhaust fan and as close to the gas collecting hood as possible. The lampblack purifier and pipe should be sealed well without damage or leakage;
饮食单位宜采取高空排放的，排风口应高于地面15米或所附属建筑物屋顶1.5米；不宜采取高空排放的，按标准采取室内净化或低空排放；不得将油烟排入下水管道；
If the dining unit should discharge at high altitude, the air outlet should be 15 meters above the ground or 1.5 meters above the roof of the attached building; If high altitude discharge is not suitable, indoor purification or low altitude discharge shall be adopted according to the standard; The lampblack shall not be discharged into the sewer pipe;
含有室内烧烤的饮食单位应安装一体化烧烤机，并对排出的油烟进行二次净化。
The catering unit with indoor barbecue shall install an integrated barbecue machine and conduct secondary purification for the lampblack discharged.
净化设备应与排风机联动，油烟净化器的风量应与排风机的风量一致，每个基准灶头少2千风量；
The purification equipment shall be linked with the exhaust fan, and the air volume of the lampblack purifier shall be consistent with that of the exhaust fan, with at least 2000 air volumes for each benchmark stove;
炉灶、蒸箱、烤炉（箱）等产生烟气的加工设施上方应设置集气罩，油烟集气罩罩口投影面积应大于灶台面，罩口下沿离地面适宜高度在1.8米左右；
A gas collecting hood shall be set above the processing facilities that produce smoke, such as stoves, steam ovens, ovens (ovens), etc. The projected area of the hood opening of the lampblack gas collecting hood shall be larger than the kitchen top, and the appropriate height from the lower edge of the hood opening to the ground shall be about 1.8 meters;
油烟气排风水平管道应设置坡度，坡面滑向集油、放油或排凝结水处，设置排油管口，管道应密封无渗漏；
The oil smoke and gas exhaust horizontal pipe shall be set with gradient, and the slope shall slide to the place where oil is collected, drained or condensed water is drained. The oil drain pipe orifice shall be set, and the pipe shall be sealed without leakage;
监测采样孔应设置内径不小于8厘米的圆形或方形监测口，检测口应采用活动挡板，检测时打开，监测完成后密闭；
The monitoring sampling hole shall be equipped with a circular or square monitoring port with an inner diameter of no less than 8 cm. The testing port shall be equipped with a movable baffle, which shall be opened during testing and closed after monitoring;
餐饮服务企业应建立环境保护管理制度，专人或委托第三方运营管理、维护保养油烟净化器，定期清理并按规定及时登记，由辖区执法中队定期验收签字，油烟净化器清洗包含但不于（集气罩、油烟净化器、除异味装置、风机、排放通道）等，集烟罩清洁无油污，净化器和排气筒周围无油污污染地面或油烟熏黑墙壁。
Catering service enterprises shall establish an environmental protection management system, assign special personnel or entrust a third party to operate, manage, maintain and maintain the lampblack purifier, clean it regularly and register it in a timely manner as required. The law enforcement squadron in the jurisdiction shall regularly accept and sign. The lampblack purifier cleaning includes but is not limited to (gas collecting hood, lampblack purifier, odor removal device, fan, emission channel), etc. The lampblack purifier shall be clean and free of oil contamination, There is no oil stain around the purifier and exhaust funnel to pollute the ground or smoke the walls.
The appearance of lampblack purification equipment shall be intact, neat and complete, and the identification shall be complete. A sign shall be set at a prominent position, indicating the origin, specification and model, treatment air volume, purification efficiency, high imported lampblack concentration, equipment resistance, origin, factory name, manufacturer address and contact information, date of manufacture, service life, production number, etc. Follow us http://www.1nightescorts.com , learn more about it!
上一篇：通风管道加工后避免堵塞两种参考方式
下一篇：实际装修厨房排烟时要了解的事项
